Electrochemical and Microstructural Characterization of Cr-Coated NdFeB in Neutral Wet Environment

Authors

  • V. Abanihi
    Department of Electrical & Electronics Engineering, Edo State University Uzairue, P.M.B. 04 Auchi, Edo State, Nigeria
  • K. K. Adama
    Department of Chemical Engineering, Edo State University Uzairue, P.M.B. 04 Auchi, Edo State, Nigeria.
  • I. B. Onyeachu
    Department of Industrial Chemistry, Edo State University Uzairue, P.M.B. 04 Auchi, Edo State, Nigeria

Keywords:

Permanent magnet, Surface Coating, Cr–oxide, Corrosion protection, EIS

Abstract

Naturally, NdFeB–based permanent magnets exhibit high chemical instability, especially, in wet environments. This makes them highly susceptible to corrosion, which leads to severe structural collapse. Applying thin surface coatings can improve the resistance to wet corrosion. In this work, 0.5 µm of chromium (Cr) film was sputtered on a sintered NdFeB–based magnet and the resistance to corrosion and microstructural damage was investigated in 3.5% NaCl solution with respect to an uncoated magnet. This was achieved by complementing potentiodynamic polarization and electrochemical impedance spectroscopy with scanning electron microscopy (SEM). The Cr coating caused a positive displacement of corrosion potential and lowered the rate of anodic dissolution. It also favored higher charge transfer resistance at the magnet–solution interface, and delivers a protection efficiency of ~ 60 %. Furthermore, grain boundary attack and deterioration were also significantly reduced by the Cr coating.

Dimensions

J. Li, X. Huang, L. Zeng, B. Ouyang, X. Yu, M. Yang, B. Yang, R.S. Rawat, & Z. Zhong, “Tuning magnetic properties, thermal stability and microstructure of NdFeB magnets with diffusing Pr-Zn films”, J. Mater. Sci. Technol. 41 (2020) 81.

O. Gutfleisch, M.A. Willard, E. Brück, C.H. Chen, S.G. Sankar, & J.P. Liu, “Magnetic materials and devices for the 21st century: stronger, lighter, and more energy efficient”, Adv. Mater. 23 (2011) 821.

J. Chen, H. Yang, G. Xu, P. Zhang, J. Lv, W. Sun, B. Li, J. Huang, D. Wang, Y. Wu, “Phosphating passivation of vacuum evaporated Al/NdFeB magnets boosting high anti-corrosion performances”, Surf. Coat. Technol. 399 (2020) 126115.

D.C. Jiles, “Recent advances and future directions in magnetic materials”, Acta Materialia 51 (2003) 5907.

D.C. Jiles, C.C.H. Lo, “The role of new materials in the development of magnetic sensors and actuators”, Sensors and Actuatuators 106 (2003) 3.

M. Drak, L.A. Dobrzanski, “Corrosion of Nd–Fe–B Permanent magnet”, Achievements in Materials and Manufacturing Engineering 20 (2007) 239.

I. Gurappa, “Corrosion characteristics of permanent magnets in acidic environments”, J. Alloy. Compd. 360 (2003) 236.

D.S. Edgley, J.M. Le Breton, S. Steyaert, F.M. Ahmed, I.R. Harris, J. Teillet, “Characterisation of high temperature oxidation of Nd-Fe-B magnets”, J. Magn. Magn. Mater. 173 (1997) 29.

A.A. El-Moneim, A. Gebert, “Electrochemical characterization of galvanically coupled single phases and nanocrystalline NdFeB-based magnets in NaCl solutions”, J. Appl. Electrochem. 33 (2003) 795.

A. Hutten, “Processing, Structure, and Property Relationships in Nd-Fe-B Magnets”, Metals 3 (1992) 11.

L.A. Dobrzanski, M. Drak, “Structure and properties of composite materials with polymer matrix reinforced NdFeB hard magnetic nanostructured particles”, Materials Processing Technology 157-158 (2004) 650.

L.A. Dobrzanski, M. Drak, “Corrosion resistance of the polymer matrix hard magnetic composite materials Nd–Fe–B”, Materials Processing Technology 164 (2005) 795.

H. Chen, X. Yang, L. Sun, P. Yu, X. Zhang, L. Luo, “Effects of Ag on the magnetic and mechanical properties of sintered NdFeB permanent magnets”, J. Magn. Magn. Mater. 485 (2019) 49.

F.M. Ahmed, I.R. Harris, “Improvement of microstructure and magnetic properties of NdFeB alloys by Nb and Co additions”, J. Magn. Magn. Mater. 320 (2008) 2808.

L.Q. Yu, Y.H. Wen, M. Yan, “Effects of Dy and Nb on the magnetic properties and corrosion resistance of sintered NdFeB”, J. Magn. Magn. Mater. 283 (2004) 353.

Y. Ouyang, R. Qiu, Y. Xiao, Z. Shi, S. Hu, Y. Zhang, M. Chen, P. Wang, “Magnetic fluid based on mussel inspired chemistry as corrosion-resistant coating of NdFeB magnetic material”, Chem. Eng. J. 368 (2019) 331.

W. Jiang, L. Shen, K. Wang, M. Xu, Z. Tian, “Study on Ni-Ni(S)-Ni(P) multilayer coating by friction-assisted jet electroplating on sintered NdFeB”, J. Alloy. Compd. 787 (2019) 1089.

H. Wu, S. Xiao, D. Chen, A.M. Qasim, K. Ding, G. Wu, P.K. Chu, “Effects of diamond like carbon film on the corrosion behavior of NdFeB permanent magnet”, Surf. Coat. Technol. 312 (2017) 66.

D. Jingjing, X. Bajin, L. Guoping, “Al–Mn coating electrodeposited from ionic liquid on NdFeB magnet with high hardness and corrosion resistance”, Applied Surface Science 305 (2014) 309.

Q. Li, Y. Xiaokui, Z. Liang, W. Juping, C. Bo, “Corrosion resistance and mechanical properties of pulse electrodeposited Ni–TiO 2 composite coating for sintered NdFeB magnet”, J. Alloys and Compounds 482 (2009) 339.

M. Shoudong, Y. Hengxiu, H. Feng, X. Tingting, S. Zhenlun, “Corrosion behaviour of sintered NdFeB coated with Al/Al 2 O 3 multilayers by magnetron sputtering”, Applied Surface Science 257 (2011) 3980.

X. Tingting, M. Shoudong, Y. Chao, W. Shaojie, S. Zhenlun, “Structure, corrosion, and hardness properties of Ti/Al multilayers coated on NdFeB by magnetron sputtering”, Vacuum 86 (2012) 1583.

Y. Xiaokui, L. Qing, Z. Shiyan, G. Hui, L. Fei, D. Yan, “Electrochemical corrosion behaviors and corrosion protection properties of Ni–Co alloy coating prepared on sintered NdFeB permanent magnet”, J Solid State Electrochem 14 (2010) 1601.

M. Chunchun, L. Xiaofang, Z. Chungen, “Cold-Sprayed Al Coating for Corrosion Protection of Sintered NdFeB”, Thermal Spray Technology 23 (2014) 456.

M. Shoudong, Y. Hengxiu, S. Zhenlun, L. Jinlong, Y. Huagen, S. Kefei, “Corrosion behaviour of sintered NdFeB deposited with an aluminium coating”, Corrosion Science 53 (2011) 1887.

X. Peng, Y. Zhang, F. Wang, “Electrochemical corrosion performance in 3.5% NaCl of the electrodeposited nanocrystalline Ni films with and without dispersions of Cr nanoparticles”, Electrochemical and Solid–State Letters 8(9) (2006) 46.

B.I. Onyeachu, X. Peng, E.E. Oguzie, C.E. Ogukwe, I. Digbo, “Characterizing the electrochemical corrosion behavior of a Ni-28wt.%Al composite coating in 3.5% NaCl solution”, Portugaliae Electrochimica Acta 33(2) (2015) 69.

S. Mao, H. Yang, Z. Song, J. Li, H. Ying, K. Sun, “Structures and properties of sintered NdFeB coated with IBAD–Al/Al 2 O 3 multilayers”, Corrosion Science 53 (2011) 1887.

I.B. Onyeachu, M.M. Solomon, K.K. Adama, F. Nnadozie, C.C. Ahanotu, C.E. Akanazu, D.I. Njoku, “Exploration of the potentials of imidazole-based inhibitor package for heat exchanger-type stainless steel during acid cleaning operation”, Arabian Journal of Chemistry 15 (2022) 103837.

K.K. Adama, Ikenna B. Onyeachu, “The corrosion characteristics of SS316L stainless steel in a typical acid cleaning solution and its inhibition by 1-benzylimidazole: Weight loss, electrochemical and SEM characterizations”, Journal of the Nigerian Society of Physical Sciences 4 (2022) 214.

I.B. Onyeachu, D.I. Njoku, S.C. Nwanonenyi, C.C. Ahanotu, K.M. Etiowo, “Investigation into the adsorption and inhibition properties of sodium octanoate against CO 2 corrosion of C1018 carbon steel under static and hydrodynamic conditions”, Scientific African 20 (2023) e01603.

A.S. Kim, F.E. Camp, “Improved Corrosion Resistance of Nd-Fe-B Magnets”, Materials and Engineering 13 (1991) 175.

S.A. Attanasio, R.M. Latanision, “Corrosion of rapidly solidified neodymium-iron-boron (NdFeB) permanent magnets and protection via sacrificial zinc coatings”, Material Science and Engineering A 198 (1995) 25.

M. Rada, A. Gebert, L. Mazilu, K. Khlopkov, O. Gutfleisch, “Corrosion studies on highly textured Nd–Fe–B sintered magnets”, Alloys and Compounds 415 (2006) 111.

Published

2023-07-24

How to Cite

Electrochemical and Microstructural Characterization of Cr-Coated NdFeB in Neutral Wet Environment. (2023). African Scientific Reports, 2(2), 102. https://doi.org/10.46481/asr.2023.2.2.102

Issue

Volume 2, Issue 2, August 2023

Section

Original Research
Copyright & Licensing

Copyright (c) 2023 V. Abanihi, K. K. Adama, I. B. Onyeachu

Creative Commons License

This work is licensed under a Creative Commons Attribution 4.0 International License.

How to Cite

Electrochemical and Microstructural Characterization of Cr-Coated NdFeB in Neutral Wet Environment. (2023). African Scientific Reports, 2(2), 102. https://doi.org/10.46481/asr.2023.2.2.102

Similar Articles

31-36 of 36

You may also start an advanced similarity search for this article.